Product ID:MOBIL AERO OIL 120
MSDS Date:01/12/1989
FSC:9150
NIIN:00-753-5059
MSDS Number: BHXTF

Emergency Phone: 703-849-3265 OR 212-883-4411

Info Phone: 800-424-9300

Cage: 3U728

Telephone: 703-998-0036

Cage: 0HZM8

MINERAL OIL, UNSPECIFIED

Fraction By Weight: >95%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ADDITIVES AND OTHER INGREDIENTS

Fraction By Weight: <5%

LD50 LC50 Mixture:ORAL LD50 (RAT) IS > 5 G/KG ESTIMATED
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ON RARE OCCASIONS, PROLONGED AND
REPEATED EXPOSURE TO OIL MIST POSES A RISK OF PULMONARY DISEASE
SUCH AS CHRONIC LUNG INFLAMMATION. THIS CONDITION IS USUALLY
ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS. SHORTNESS
OF BREATH AND COUGH ARE THE MOST COMMON SYMPTOMS. ASPIRATION MAY
LEAD TO CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:INHALATION: PULMONARY EDEMA AND HEMORRAGE WHICH
MAY BE FATAL. INCREASED RESPIRATION RATE, INCREASED HEART RATE, AND
A BLUISH DISCOLORATION OF THE SKIN. COUGHING, CHOKING, AND GAGGING
ARE OFTEN NOTED A T THE TIME OF ASPIRATION. GASTROINTESTINAL
DISCOMFORT MAY DEVELOP, FOLLOWED BY VOMITTING.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: MAY ACT AS A
LAXATIVE. DO NOT INDUCE VOMITING. RELATIVELY NON-TOXIC UNLESS
ASPIRATED.

Flash Point Method:COC
Flash Point:>470F,>243C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE FROTHING.

Spill Release Procedures:CONTAIN SPILL IMMEDIATELY. DO NOT ALLOW SPILL
TO ENTER SEWERS OR WATERCOURSES, REMOVE ALL SOURCES OF IGNITION.
ABSORB WITH APPROPRIATE INERT MATERIAL SUCH AS SAND, CLAY, ETC.
LARGE SPILLS MAY BE PICKE D UP USING VACUUM PUMPS, SHOVELS,
BUCKETS, ETC.

Handling and Storage Precautions:PERSONS WHO REGULARLY HANDLE USED
MOTOR OIL SHOULD MINIMIZE CONTACT WITH THE OIL. WASH ANY SKIN
CONTACT AREAS AND REMOVE OIL SOAKED CLOTHING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
WITH A DUST AND MIST FILTER IF REQUIRED. PROTECTION IS NOT REQUIRED
UNDER NORMAL USE CONDITIONS.
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE.
USE MECHANICAL (GENERAL) VENTILATION IF IN ENCLOSED AREA.
Protective Gloves:IMPERVIOUS SYNTHETIC RUBBER IF REQUIRED.
Eye Protection:USE CHEMICAL SAFETY GOGGLES AS REQUIRED.
Other Protective Equipment:FOR PROLONGED OR REPEATED EXPOSURES, USE
IMPERVIOUS SYNTHETIC RUBBER CLOTHING (BOOTS, APRONS, ETC.).
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
NONE

HCC:V6
Boiling Pt:B.P. Text:>600F,>316C
Vapor Pres:<0.1
Spec Gravity:0.88
Viscosity:1635 SUS@100F
Evaporation Rate & Reference:NIL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OIL; MILD ODOR
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CARBON MONOXIDE.

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL LAWS AND REGULATIONS. RECYCLE IF POSSIBLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.